[C38] fuel problem
1derful at comcast.net
1derful at comcast.net
Tue Aug 30 11:17:24 EDT 2016
These instructions are not in the manual that comes with the engine
----- Original Message -----
From: "littlebreeze" <littlebreeze at comcast.net>
To: "Catalina" <listserve at catalina38.org>
Sent: Tuesday, August 30, 2016 6:35:56 AM
Subject: Re: [C38] fuel problem
Nice
Loyality above all else, except honor.
-------- Original message --------
From: Patrick Harpole <1derful at comcast.net>
Date: 8/29/16 22:12 (GMT-08:00)
To: Catalina 38 Listserve <listserve at catalina38.org>
Subject: Re: [C38] fuel problem
My fuel problem's solved.
If you run out of diesel you need to:
1. Install fuel
2.turn key 1/4 turn which turns on fuel pump
3. Bleed fuel filter
4. Bleed at internal fuel pump
5. Loosen nuts which hold fuel tubes to engine
6. Turn key to starting for 10 seconds which activates internal pump
7. Tighten nuts
8. Start engine
Patrick
Note: turning key 1/4 only activates the external fuel pump so you will not get the air out of the tunes that go to cylinder
Sent from my iPhone
On Aug 29, 2016, at 4:51 PM, S Orton < ssorton at hotmail.com > wrote:
I had this problem 10 + yrs. ago. The engine would run for a couple hours and shut down for lack of fuel, wait a half hour or so, restart and run for 1/2 hour, etc. and repeat. After changing everything, over a period of years, plus cleaning the tank in a radiator shop, I found the very simple problem- the 1/4 inch pick up hose laying on the very bottom of the tank had very small copper screen stuck into the hose end and was easily clogged. I removed the screen and the engine has NEVER failed since. Let the suction filter do it's job- no screens up stream of the filter.
Steve O (Santa Susanna, 304)
Date: Mon, 29 Aug 2016 18:48:41 +0000
From: dickkilroy at comcast.net
To: listserve at catalina38.org
Subject: Re: [C38] fuel problem
Patrick: As others have said be aware of the small filter in the Facet fuel pump, it can plug very easily. Depending on how your system is set up it can really hurt. I changed to a Sherwood pump, higher flow, no filter. The facet shaft can also ware easily and cause leaking.
Dick
From: "Patrick Harpole" < 1derful at comcast.net >
To: "Catalina 38 Listserve" < listserve at catalina38.org >
Sent: Saturday, August 27, 2016 2:31:13 PM
Subject: Re: [C38] fuel problem
Going to boat now
Plan:
Check fuel tank for sludge
Replace fuel filter
Any other thoughts?
Patrick
925-323-6398
Sent from my iPhone
On Aug 26, 2016, at 8:57 PM, littlebreeze < littlebreeze at comcast.net > wrote:
<blockquote>
Patrick did you ever get your problem fixed.
Loyality above all else, except honor.
-------- Original message --------
From: 1derful at comcast.net
Date: 8/21/16 21:14 (GMT-08:00)
To: Catalina < listserve at catalina38.org >
Subject: [C38] fuel problem
100 yards from slip "Blue Eyes" engine sputtered then quit. I started her 3 time and she lasted about 30 second. My mate wisely said,"Is she out of fuel?" Gauge was on "E." Fortunately I had 5 gallons of diesel. This addition hasn't led to her starting. I unscrewed the air bleeds to the cylinder. No fuel. The fuel pump makes noise so I assume she works. I removed the top of the fuel filter.............canister was low. Turning on the accessory switch filled the fuel filter but fuel still doesn't get to the air bleeds at the cylinders.
Any thoughts?
Patrick
<blockquote>
_______________________________________________
Listserve mailing list
Listserve at catalina38.org
http://catalina38.org/mailman/listinfo/listserve_catalina38.org
</blockquote>
_______________________________________________
Listserve mailing list
Listserve at catalina38.org
http://catalina38.org/mailman/listinfo/listserve_catalina38.org
_______________________________________________ Listserve mailing list Listserve at catalina38.org http://catalina38.org/mailman/listinfo/listserve_catalina38.org
</blockquote>
<blockquote>
_______________________________________________
Listserve mailing list
Listserve at catalina38.org
http://catalina38.org/mailman/listinfo/listserve_catalina38.org
</blockquote>
_______________________________________________
Listserve mailing list
Listserve at catalina38.org
http://catalina38.org/mailman/listinfo/listserve_catalina38.org
-------------- next part --------------
An HTML attachment was scrubbed...
URL: <http://catalina38.org/pipermail/listserve_catalina38.org/attachments/20160830/7a7fa9ea/attachment-0001.htm>
More information about the Listserve
mailing list